ENGINE:
Gasoline Engine: Cylinder block and all internally lubricated parts, including crankshaft, rod and main bearings, cam bearings, connecting rods, wrist pins, pistons, piston rings, camshaft, cam phaser, cam tower, lifters, cylinder head, valves and guides, valve springs, rocker arms, pushrods, timing chain and sprockets, oil pump, oil pump drive sprocket, oil pump housing, oil pump pressure relief valve, timing chain housing, intake and exhaust manifolds, engine mounts, flexplate, flywheel, ring gear, balance shafts, harmonic balancer and retainer bolt, crankshaft pulley, engine oil cooler, oil filter adapter/housing, engine oil sending unit, thermostat and housing, water pump, temperature sending unit, expansion plugs, mechanical fuel supply pump, vacuum pump, dipstick and tube, and fasteners for these components. The oil pan and valve covers are only covered when they have failed as a result of progressive damage from an internally lubricated Covered Part referenced herein.
In addition to the above, the following parts are covered for Diesel Engines: Fuel distributor, fuel injection pump, fuel regulator and injectors. The auxiliary fuel pump is excluded.
Turbocharged/Supercharged Engine: Turbocharger, supercharger, waste gate controller, intercooler, hard lines, compressor, clutch and pulley, bypass valve, injection pump, and lines and nozzles. Housing is only covered if damaged by an internally lubricated part.
TRANSMISSION:
Automatic: Case and all internally lubricated parts, including oil pump, valve body, torque converter, governor, main shaft, input/output shafts, clutches, bands, drums, gear sets, bearings, bushings, solenoids, TV cable, electronic shift control unit, computer operated clutch, clutch plates, servo units, cooler, dipstick and tube, and fasteners for these components.
Standard (Manual): Case and all internally lubricated parts, including main shaft, input/output shafts, gear sets, shift forks, synchronizers, bearings, bushings, shift linkage and cables, transmission mounts, vacuum modulator and fasteners for these components.
DRIVETRAIN:
Front Wheel Drive: Final drive housing and all internally lubricated parts, including carrier case, gear sets, chain and sprockets, bearings, bushings, axle shafts, front hub bearings, rear hub bearings, constant velocity joints, double offset joint, drive shaft support, drive shaft//yokes, four-wheel drive actuator, locking hub mechanisms, propeller shafts and universal joints, and fasteners for these components.
Rear Wheel Drive: Drive axle housing and all internally lubricated parts, including carrier case, gear sets, bearings, bushings, limited slip clutch pack, axle shafts, front hub bearings, rear hub bearings, constant velocity joints, double offset joint, drive shaft support, drive shaft/yokes, four-wheel drive actuator, locking hub mechanisms, propeller shafts and universal joints and fasteners for these components.
Transfer Case – 4X4/AWD: Case and all internally lubricated parts, including main shaft, gear sets, chain and sprockets, bearings, bushings, and fasteners for these components, four-wheel drive selector switch, transfer case module, electronic and vacuum engagement components, including manufacturer’s all-wheel drive systems such as Quattro, xDrive, 4-Matic, etc.
HYBRID VEHICLE COMPONENTS:
Hybrid battery junction block, hybrid battery main battery cable, and electric alternating current compressor, electric motor/ generator(s) and all internal components, onboard battery charging system including charge controller, plug in outlets, plug in cable and trickle charge cable; electric air conditioning compressor and motor, inverter/converter/transformer units and all internal components, inverter/converter/transformer units cover, continuously variable transmission (CVT) and all internal components, power split device and all internal components, reduction/reducer box and all internal components, and fasteners for the components listed above, motor/generator belt tensioner, drive motor dampener, voltage inverter reservoir, three-phase high voltage cables, hydraulic or electric regenerative braking system, onboard computer system, including all relays, sensors, ECU & ECM (electronic control units/electronic control modules), power switch/button and controller/electronic throttle control system.
AIR CONDITIONING AND HEATING:
Condenser, evaporator, serpentine belt tensioner, compressor, clutch and pulley, compressor clutch coil, orifice tube, accumulator, HVAC control module, high/low pressure cutoff switches, high/low pressure hoses, pressure cycling switch, thermostat, drier, temperature control head, fasteners for these components, and refrigerant if necessary for a Covered Repair.
BRAKES:
Wheel cylinders, master cylinder, combination valve, assist booster, proportioning valve, hydraulic lines and fittings, disc brake calipers, hard lines and fittings, backing plates, springs, clips and retainers, self-adjusters, parking brake linkage and cables, and fasteners for these components, ABS control module, ABS pump, ABS sensors, ABS accumulator, ABS motor and rear actuators.
ELECTRICAL:
Voltage regulator, alternator, front and rear windshield wiper motors, front and rear windshield wiper delay controller, back up lamp switch, brake light switch, hazard warning switch, headlamp switch, ignition switch, multi-function switch, neutral safety switch, turn signal switch, wiper switch starter motor and drive, starter solenoid, distributor, pick-up coil, electronic ignition module, ignition coils, integrated power distribution module (IPDM), fuel pump relay, crankshaft position sensor, camshaft position sensor, vehicle speed sensor, electronic off headlamp sensor, power antenna motor body control module, engine control module, engine management control unit, Keyless entry system, instrument gauges, compass display, thermometer display, power steering electronic control unit, cruise control system, power seat motor, power seat transmission, power window motor, power window regulator, low fuel sensor, low coolant sensor, low oil sensor, power antenna motor, electronic rear view mirror motor, headlight door motor, power sunroof motor, convertible top motor, electronic instrument cluster, electronic level control compressor, electronic level control sensor, wiring harnesses, back up lamp switch, brake light switch, hazard warning switch, headlamp switch, ignition switch, multi-function switch, neutral safety switch, turn signal switch, wiper switch, power window switch, washer motor, wiper circuit board, coil pack, manifold air temperature sensor (MAT), power door lock actuator/switch, power mirror switch, power seat switch, power trunk/liftgate lock actuator, seat memory switch, seat temperature switch, sunroof switch, traction control switch, transmission position switch, transmission temperature switch, accelerator pedal position sensor, air temp sensor, ambient temp sensor, idle air control valve, idle speed control motor, knock sensor, oxygen sensor, and throttle position sensor. Analog gauges, brake fluid level sensor, brake fluid pressure sensor, cabin temperature sensor, camshaft position sensor, crankshaft position sensor, oil pressure sensor, oil temperature sensor, seat position sensor, transmission position sensor, transmission temperature sensor, fuel level sensor, coolant level sensor, coolant temperature sensor and relay, electronic fuel injection system except exhaust gas recirculation valve, electronic suspension sensors, electronic suspension controller and limiting valve, electronic suspension lines and electronic throttle body, manifold absolute pressure sensor (MAP), mass air flow sensor (MAF) and power door lock actuators, all manually operated switches, and wiring harnesses for listed covered components.
FRONT AND REAR SUSPENSION:
Bump stop cushions, torsion bar mounts and bushings, upper and lower control arms, control arm shafts and bushings, upper and lower ball joints, including dust boots, steering knuckle (spindle), spindle support, stabilizer shaft, stabilizer linkage, including mounts and bushings, kingpins, wheel bearings and fasteners for the components listed above, electronic suspension actuator/motor and compressor, electronic suspension sensors, electronic suspension controller and limiting valve, electronic suspension lines, air suspension springs, radius arm and bushings, torsion bars, stabilizer bar, bushings, struts, strut bearing plates, pannard bar, track bar, suspension bumpers, leaf springs, leaf spring shackles and hardware, and fasteners for these components.
FUEL DELIVERY:
Fuel injectors, fuel injection pump, primary fuel pump, secondary fuel pump, fuel tank sending unit, and fuel tank hard lines.
STEERING:
Housing/case and all internally lubricated parts (examples include rack and pinion equipped valve assembly, sector shaft, rack mounts and cushions, inner rod ends and bellows boots, speed sensor or steering gear equipped pitman shaft and valve assembly and bearings), bushings, pitman arm, center link, idler arm, power steering pump/electric steering motor, power steering pump pulley, fluid reservoir, coupling, and fasteners for the components listed above. The steering box is only covered if damaged by an internally lubricated part.
MISCELLANEOUS COMPONENTS:
Fuel tank, radiator, radiator fan, including fan clutch, fan motor, fan blade, and fan relay, temperature sensor and relay, struts, including upper mount and pivot bearing assembly, heated back glass, windshield wiper washer pump(s), heater-A/C blower motor, heater core assembly, heater control valve, expansion valve, orifice tube and receiver/dryer, horn assembly and clutch starter interlock switch.
TECHNOLOGY:
Adaptive lighting control motors, actuators, and sensors (composite headlight assembly, only as a result of failure of a listed component); audio system, including displays and control modules; auto dimmers; blind spot monitoring control module and sensors; bluetooth systems, module, and microphone; collision avoidance systems; cruise control systems, including adaptive/autonomous cruise control technologies, control unit, sensors, and cameras; driver information center; driver recognition systems, entertainment technology; eye detection systems, factory installed vehicle hot-spot/cellular transceiver; hands free systems and controls, heads-up display systems; HomeLink®/garage door control transmitter; humidity sensors; infrared systems; keyless access systems; lane departure systems; multimedia interface systems; navigation packages; power trunk/lift gate motor and sensors; proximity sensors; rear monitoring cameras; rear, front, and side mounted cameras and control unit; rest recommendation systems; seat heaters and coolers; self-parking systems, module, sensors, and cameras; SOS systems; touch screen technology; USB ports; vibration sensors; voice recognition/ command systems.
SEALS & GASKETS:
Covered only if required in connection with a Covered Repair.